language
Motorcycle wearing parts maintenance cycle table
Release time:
2024-09-20
Vulnerable parts refer to parts with a short service life. If the vulnerable parts of a motorcycle are not replaced in time, it will not only damage the vehicle, but also leave hidden dangers to driving safety.
Vulnerable parts refer to parts with a short service life. If the vulnerable parts of a motorcycle are not replaced in time, it will not only damage the vehicle, but also leave hidden dangers to driving safety. So, for motorcycle wearing parts, how long will it be replaced?
Different brands have different warranty periods for wearing parts, ranging from a minimum of three months to one year or from 3000 kilometers to 20000 kilometers. Because the damage of wearing parts is difficult to define, the warranty period is much shorter than the warranty period of the whole vehicle, such as glass, light bulbs, wipers, brake pads, etc., it is difficult to determine whether it is caused by improper use by the owner.
1. Brake pads
The replacement cycle is about 30000 kilometers!
The quality of the brake pads is related to the safety of the people in the car and must not be ignored. The front brake pads of disc brake motorcycles are checked and replaced every 15000 kilometers, and the rear brake pads are replaced every 30000 kilometers. When riding, the brakes are fierce and the brake pads wear faster. Replace the front brake pads about 10000 kilometers. Check the brake pads every 5000 kilometers. The thickness of the new brake pads is generally about 1cm. When the naked eye observes that the thickness is only about 1/3 of the original thickness (about 0.3cm), it is ready to be replaced at any time. In addition, the brake disc is more wear-resistant than the brake pad. When replacing the brake pad 2-3 times, replace the brake disc once.
2. Battery
Replacement cycle 30000 kilometers or 2-3 years!
Although there is a loss of power during the operation of the motorcycle, the battery is charged at the same time. After flameout, the battery is equal to stop charging and blindly discharge, accelerating the loss of electrolyte gasification. After the flameout, a long time to rely on the battery power to maintain the operation of the audio system, will also increase the burden. Generally, the original battery of a new car can be used for more than 3 years, if it has been used for almost two years, it should be noted.
3. Spark plug
Replacement cycle 10000-20000km!
Spark plugs can cause difficulty in cold start of the car, frustration when driving, idling jitter, reduced engine acceleration performance, insufficient power, and increased fuel consumption. The service life of nickel-copper spark plugs is 1-20000 kilometers, and that of platinum/iridium spark plugs is 3-50000 kilometers. If the owner bought a spark plug, he can also clean and maintain it or replace it with a new spark plug.
4. Tires
Replacement cycle 30000-40000km!
Tires are the most easily worn parts of all parts, and when they touch the ground, they are prone to accidents. Especially when running at high speed or on mountain roads, there is a great potential safety hazard. The general replacement cycle is 30000 to 40000 kilometers. When the tread pattern has reached the wear indicator mark, it needs to be replaced in advance. When driving, try to walk on a smooth road to extend tire life.
5. Drive belt and chainset
The replacement cycle belt is 50000 kilometers or 4 years, and the tooth disc chain is 2 years and 20000 kilometers!
Because the transmission belt is a continuously variable transmission, the impact force is relatively small, so the replacement cycle has been extended. Because the chainset chain is used for gear cars, the impact and wear are relatively large, so the replacement cycle should be shortened.
6. Engine oil, gear oil
When replacing, it depends on whether the quality of the oil is mineral oil or synthetic oil. The mineral oil is replaced once about 3000 kilometers, and the fully synthetic oil is replaced once 5000 kilometers. The replacement cycle of the gasoline filter and the external steam filter is 10000-20000 kilometers, and the oil pump is recommended to be replaced at 60000 kilometers.
The gear oil is changed every 5000 kilometers. Motorcycle wearing parts maintenance cycle table, quickly collect
7. Air filter element
Replacement cycle of one year!
The time to replace the air filter element mainly depends on the external environment. Under normal circumstances, the maintenance cycle of the air filter element is 10000 kilometers or about once a year. In the case of severe smog, it is best to use the car for half a year or 70000 kilometers. Replace it once.
8. Brake fluid
Replacement cycle 50000km or 2 years!
Expired brake fluid will produce emulsified deterioration, resulting in a decline in braking efficiency or even failure. It is wrong to think that the brake fluid has not turned black and the brakes are not soft and there is no need to replace it. Check its quality and performance in time according to climate, environmental conditions, seasonal changes and working conditions. Usually the brake fluid is replaced after two years or 50000 kilometers of use. When replacing, it is necessary to find out whether it is DOT4 or DOT3.
Regular inspection and maintenance of your car is a responsible behavior for yourself and other road users.
Related News
CHONGQING YONGFENG ELITE AUTO PARTS CO., LTD.
Address: No.23, Jiu'yang Rd., Nan'jin Subdistrict, He'chuan District
Tel: +86023-42815139
CHONGQING YONGFENG ELITE VALVE CO.，LTD.
Address: No.68 Ankang sub Rd.Airport Industrial parkYubei District Chongqing,401120,PRC
Tel: +86023-42815178
©2024 Chongqing Yongfeng Jingqi Auto Parts Co., Ltd.
Powered by www.300.cn | SEO [Privacy Statement]
Business License